Advertisem*nts
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Expedition (1997, 1998, 1999, 2000, 2001, 2002).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
See Also
Fuse Box Diagram Ford Expedition (U553; 2018-2021)Fuse Box Diagram Ford Expedition (U324; 2007-2014)Ford Expedition 2003-2006 fuse box diagram with assignment and relay location - Fuse in car2004 Ford Expedition fuse box diagram - StartMyCarTo check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box Diagram
The fuse panel is located below and to the left of the steering wheel by the brake pedal. Pull the panel cover outward to access the fuses. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
| № | A | Description |
|---|---|---|
| 1 | 25 | Audio |
| 2 | 5 | Overhead Trip Computer, |
| Electronic Automatic Temperature Control (EATC), | ||
| Powertrain Control Module (PCM), | ||
| Cluster | ||
| 3 | 20 | Cigar Lighter, |
| OBD-II Scan Tool Connector | ||
| 4 | 7.5 | Remote Entry Module, |
| Mirrors, | ||
| Memory Functions (Seats and Pedals) | ||
| 5 | 15 | Speed Control Module, |
| Reverse Lamp, | ||
| EVO Module, | ||
| Climate Mode Switch (Front Blower Relay), | ||
| Daytime Running Lamp Relay, | ||
| Reverse Sensing System, | ||
| Autolock, | ||
| E/C Mirror | ||
| 6 | 5 | Cluster, |
| Overhead Trip Computer, | ||
| Compass, | ||
| Brake Shift Interlock Solenoid, | ||
| Air Suspension Module, | ||
| GEM Module, | ||
| EVO Steering Sensor, | ||
| Heated Mirror, | ||
| Rear Defroster, | ||
| Reverse Sensing System | ||
| 7 | 5 | Aux A/C Blower Relay (via fuse 22) |
| 8 | 5 | Radio, |
| Remote Entry Module, | ||
| GEM Module | ||
| 9 | - | Not Used |
| 10 | - | Not Used |
| 11 | 30 | Front Washer Pump Relay, |
| Wiper Run/Park Relay, | ||
| Wiper Hi/LO Relay, | ||
| Windshield Wiper Motor, | ||
| Rear Washer Pump Relay | ||
| 12 | 15 | Air Suspension Switch |
| 13 | 20 | Stop Lamp Switch (Lamps), |
| Turn/Hazard Flasher, | ||
| Speed Control Module | ||
| 14 | 15 | Rear Wipers, |
| Running Board Lamps, | ||
| Battery Saver Relay, | ||
| Interior Lamp Relay, | ||
| Accessory Delay Relay (Power Windows, Moonroof, Flip Windows) | ||
| 15 | 5 | Stop Lamp Switch, (Speed Control, Brake Shift Interlock, ABS, PCM Module Inputs, Air Suspension Module, Autolock), |
| GEM Module | ||
| 16 | 20 | Headlamps (Hi Beams), |
| Cluster (Hi Beam Indicator) | ||
| 17 | 10 | Heated Mirrors, |
| Heated Grid Switch Indicator | ||
| 18 | 5 | Instrument Illumination (Dimmer Switch Power) |
| 19 | - | Not Used |
| 20 | 5 | Audio, |
| Air Suspension Module, | ||
| GEM Module, | ||
| Memory Module | ||
| 21 | 15 | Starter Relay, |
| Fuse 20, | ||
| Transmission Range Switch | ||
| 22 | 10 | Air Bag Module, |
| Climate Mode Switch (Blower Relay), | ||
| EATC, | ||
| EATC Blower Relay, | ||
| Feeds Fuse 7 | ||
| 23 | 10 | Aux A/C, |
| Heated Seats, | ||
| Trailer Tow Battery Charge, | ||
| Turn/Hazard Flasher, | ||
| 4x4 Clutch Relay, | ||
| Overhead Console, | ||
| E/C Mirror, | ||
| 4 Wheel Anti-Lock Brake System (4WABS) Module | ||
| 24 | - | Not Used |
| 25 | - | Not Used |
| 26 | 10 | Right Side Low Beam Headlamp |
| 27 | 5 | Foglamp Relay and Foglamp Indicator |
| 28 | 10 | Left Side Low Beam Headlamp |
| 29 | 5 | Autolamp Module, |
| Transmission Overdrive Control Switch | ||
| 30 | 30 | Passive Anti Theft Transceiver, Cluster, Ignition Coils, Powertrain Control Module Relay |
| 31 | 10 | Rear Integrated Control Panel (Audio), |
| CD Player | ||
| Relay 1 | - | Interior Lamp Relay |
| Relay 2 | - | Battery Saver Relay |
| Relay 3 | - | Rear Window Defroster Relay |
| Relay 4 | - | One Touch Down Window Relay |
| Relay 5 | - | ACC Delay Relay |
Advertisem*nts
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
Diagram (Version 1)
| № | A | Description |
|---|---|---|
| 1 | 20 | Trailer tow backup & tail lamps |
| 2 | 10 | Airbag diagnostic monitor |
| 3 | 30 | Power locks |
| 4 | 15 | Air suspension |
| 5 | 20 | Horn |
| 6 | 30 | Engine minifuse box fuses #3 and #5 |
| 7 | 15 | Park and tail lamps |
| 8 | 30 | Headlamps |
| 9 | 15 | Fog lamps and DRL |
| 10 | 25 | Auxiliary instrument panel (I/P) power point |
| 11 | 25 | Auxiliary console power point |
| 12 | 10 | Rear wiper |
| 13 | 30 | Auxiliary blower |
| 14 | 60 | Four wheel anti-lock brake system (4WABS) |
| 15 | 50 | Air suspension compressor |
| 16 | 40 | Trailer tow battery charge, engine minifuse box fuse #2, engine minifuse box fuse #4 |
| 17 | 30 | Four-wheel drive (4WD) transfer case motor and clutch |
| 18 | 30 | Driver power sea |
| 19 | 20 | Fuel pump |
| 20 | 50 | Junction box ignition switched feed |
| 21 | 50 | Junction box ignition switched feed |
| 22 | 50 | Junction box battery feed |
| 23 | 40 | Front blower |
| 24 | 30 | Powertrain control module power |
| 25 | 30 C.B. | Windows |
| 26 | - | not used |
| 27 | 40 | Heated backlite and mirrors |
| 28 | 30 | Trailer tow electric brake |
| 29 | 30 | Hybrid fan, moon roof, flip windows |
| 1 | - | not used |
| 2 | - | PCM diode |
| 1 | - | Windshield wipers high/low speed |
| 2 | - | Windshield wipers run/park |
| 3 | - | Front washer pump relay |
| 4 | - | Fuel pump relay |
| 5 | - | Horn relay |
| 6 | - | PCM power relay |
Advertisem*nts
Diagram (Version 2)
| № | A | Description |
|---|---|---|
| 1 | 20 | Power Point |
| 2 | 30 | Powertrain Control Module |
| 3 | 30 | Headlamps/Autolamps |
| 4 | 20 | Console Powerpoint |
| 5 | 20 | Trailer Tow Backup/Park Lamps |
| 6 | 15 | Parklamps/Autolamps, Feeds Passenger Compartment Fuse 18 |
| 7 | 20 | Horn |
| 8 | 30 | Power Door Locks |
| 9 | 15 | Daytime Running Lamps (DRL), Fog Lamps |
| 10 | 20 | Fuel Pump |
| 11 | 20 | Alternator Field |
| 12 | 10 | Rear Wipers |
| 13 | 15 | A/C Clutch |
| 14 | - | Not Used |
| 15 | 10 | Running Board Lamps |
| 16 | - | Not Used |
| 17 | 10 | Flip Windows |
| 18 | 15 | Powertrain Control Module, Fuel Injectors, Fuel Pump, Mass Air Flow Sensor |
| 19 | 10 | Trailer Tow Stop and Right Turn Lamp |
| 20 | 10 | Trailer Tow Stop and Left Turn Lamp |
| 21 | - | Not Used |
| 22 | - | Not Used |
| 23 | 15 | HEGO Sensors, Canister Vent, Automatic Transmission, CMS Sensor |
| 24 | - | Not Used |
| 101 | 30 | Trailer Tow Battery Charge |
| 102 | 50 | Four Wheel Antilock Brake Module |
| 103 | 50 | Junction Block Battery Feed |
| 104 | 30 | 4x4 Shift Motor & Clutch |
| 105 | 40 | Climate Control Front Blower |
| 106 | - | Not Used |
| 107 | - | Not Used |
| 108 | 30 | Trailer Tow Electric Brake |
| 109 | 50 | Air Suspension Compressor |
| 110 | 30 | Heated Seats |
| 111 | 40 | Ignition Switch Battery Feed (Run/Start Circuit) |
| 112 | 30 | Drivers Power Seat, Adjustable Pedals, Memory Module |
| 113 | 40 | Ignition Switch Battery Feed (Run and Accessory Circuits) |
| 114 | 30 | Climate Control Auxiliary Blower |
| 115 | - | Not Used |
| 116 | 40 | Rear Window Defroster, Heated Mirrors |
| 117 | - | Not Used |
| 118 | - | Not Used |
| 201 | - | Trailer Tow Park Lamp Relay |
| 202 | - | Front Wiper Run/Park Relay |
| 203 | - | Trailer Tow Backup Lamp Relay |
| 204 | - | A/C Clutch Relay |
| 205 | - | Rear Wiper Down |
| 206 | - | Foglamp Relay |
| 207 | - | Front Washer Pump Relay |
| 208 | - | Rear Washer Pump Relay |
| 209 | - | Rear Wiper Up |
| 301 | - | Fuel Pump Relay |
| 302 | - | Trailer Tow Battery Charge Relay |
| 303 | - | Wiper Hi/Lo Relay |
| 304 | - | Powertrain Control Module Relay |
| 401 | - | Not Used |
| 501 | - | Powertrain Control Module Diode |
| 502 | - | A/C Clutch Diode |
| 503 | - | Not Used |
| 601 | 30 | Delayed Accessory (Power Windows, Flip Windows, Moonroof) |
| 602 | - | Not Used |
Advertisem*nts
Primary battery fuses (megafuses)
The primary battery fuses are located in the engine compartment near the battery. Ford recommends that a qualified service technician service the mega fuses.
| № | A | Description |
|---|---|---|
| 1 | 175 | Power network box megause |
| 2 | 175 | Alternator megafuse |
| 3 | 20 | Alternator field minifuse |
Engine mini fuse box
The engine mini fuses are located on the driver’s side of the engine compartment.
| № | A | Description |
|---|---|---|
| 1 | 5 | Powertrain control module (PCM) |
| 2 | 20 | Trailer tow stop/turn lamps |
| 3 | 10 | Audio rear integrated control panel (RICP), compact disc changer, radio |
| 4 | 10 | Running board lamps |
| 5 | 20 | Amplifier, subwoofer amplifier |
| 6 | - | Not Used |
Advertisem*nts
